Product ID:ZE-3 ZYGLO EMULSIFIER
MSDS Date:06/22/1989
FSC:6850
NIIN:00-782-2738
MSDS Number: BFPNK

MAGNAFLUX CORPORATION

7300 W.LAWRENCE AVENUE
CHICAGO, IL 60656-3504
US

Emergency Phone: 807-867-8000

Info Phone: 807-867-8000

Preparer: BRUCE C. GRAHAM, CH. CHEM

Cage: 37676

ILLINOIS TOOL WORKS INC MAGNAFLUX DIV

GLENVIEW, IL 60025 US

Telephone: 847-657-5300/

Cage: 37676

MINERAL OIL (EXPOSURE REGULATED AS 'OIL MIST')

CAS: 8012-95-1

RTECS: PY8030000

Fraction By Weight: 50.0%

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3/10 STEL;9192

UNIDENTIFIED COMPONENTS

Fraction By Weight: 50.0%

Health Hazards Acute and Chronic:ACUTE:MAY IRRITATE EYES.SEE
OVEREXPOSURE SYMPTOMS.
Effects of Overexposure:INHALATION: NOT LISTED BY MANUFACTURER;
HOWEVER,FINE SPRAY/MIST MAY IRRITATE BREATHING PASSAGES; EYES:
LIQUID/MIST CAUSES IRRITATION; SKIN: PROLONGED OR REPEATED CONTACT
CAUSES IRRITATION BY DISSOLVIN G SKIN OILS; INGESTION: CAUSES
GASTRIC UPSET.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY THE MANUFACTURER.

First Aid:INHALATION: REMOVE TO FRESH AIR; SKIN: REMOVE CONTAMINATED
CLOTHES.WASH OFF PROMPTLY WITH SOAP & WATER.USE SOOTHING LOTION.GET
MEDICAL HELP IF IRRITATION PERSISTS; EYES: IMMEDIATELY RINSE EYES
WITH CO PIOUS AMOUNT OF WATER.GET MEDICAL ASSISTANCE IF IRRIT ION
PERSISTS; INGESTION: DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION
IF INGESTED.

Flash Point Method:PMCC
Flash Point:325F/163C
Extinguishing Media:CARBON DIOXIDE,FOAM
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:WHEN INVOLVE IN COMBUSTION,MAY EMIT TOXIC
GASES AT OR ABOVE DECOMPOSITION TEMPERATURE.

Spill Release Procedures:REMOVE IGNITION SOURCES.SMALL SPILL:WIPE UP OR
MOP UP BUT DO NOT BREATHE VAPORS.PLACE RAGS IN CLOSED DRUMS; LARGE
SPILL: WEAR PERSONAL SAFETY EQUIPMENTS.DIKE AREA FAR AHEAD.ABSORB
LIQUID WITH COMMERCI AL ABSORBENT.TRANSFER WASTE MATL IN SALVAGE
TANKS.

Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES IN WELL
VENTILATED AREA.AVOID AGAINST PHYSICAL DAMAGE TO CONTAINERS.KEEP
CONTAINERS TIGHTLY CLOSED.
Other Precautions:DO NOT BREATHE VAPORS.DO NOT SMOKE WHILE USING.DO NOT
HEAT ABOVE 130F(54C).AVOID FREQUENT OR PROLONGED SKIN CONTACT.

Respiratory Protection:USE NIOSH APPROVED RESPIRATOR FOR CONFINED
AREAS.
Ventilation:GENERAL ROOM VENTILATION TO KEEP BELOW TLV LIMITS.
Protective Gloves:USE NITRILE RUBBER GLOVES IF NEEDED
Eye Protection:FULL GOGGLES/SAFETY GLASSES W/SIDESHIELD
Other Protective Equipment:NOT KNOWN
Work Hygienic Practices:WASH OFF PROMPTLY WITH WATER.AVOID SKIN
CONTACT.
Supplemental Safety and Health
NSN IS FOR TYPE II,METHOD B OF MIL-I-25135D;THIS ENTRY DESCRIBES ZE-3
EMULSIFIER AS SINGLE ITEM OF TYPE II,METH B;ZE-3 ALSO GOES WITH
SKL-LO PENETRANT AS A PART OF KIT UNDER ABOVE TYPE/METHOD;QPL-2513
5-15 ALSO QUALIFIED THIS PRODUCT TO GO WITH SEVERAL OTHER
PENETRANTS IN VARIOUS KITS OF TY I,METH A/B/C/D & LVL 1/2/3/4.

HCC:N1
Boiling Pt:B.P. Text:>450F/>232C
Vapor Pres:0.3 @ 100F
Vapor Density:>1.0
Spec Gravity:0.945
pH:8.0
Solubility in Water:NEGLIGIBLE
Appearance and Odor:VISCOUS PINK LIQUID

Stability Indicator/Materials to Avoid:YES
NONE STATED BY MANUFACTURER
Stability Condition to Avoid:HEAT,HIGH TEMPERATURES
Hazardous Decomposition Products:EMITS OXIDES OF CARBON IF BURNING

Waste Disposal Methods:INCINERATE OR DISPOSE OF AS EPA HAZARDOUS WASTE
D001 (IGNITABLE WASTE),IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL,STATE,LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.